倾斜微孔密封端面气体润滑动压效应实验研究

中国机械工程 ›› 2013, Vol. 24 ›› Issue (6): 831-835.

倾斜微孔密封端面气体润滑动压效应实验研究

白少先;柏林清;孟祥铠;李纪云;彭旭东

浙江工业大学，杭州，310032

出版日期:2013-03-25 发布日期:2013-04-08
基金资助:
国家自然科学基金资助项目（50805130）；高等学校博士学科点专项科研基金资助项目(20103317110002)；浙江省公益性技术应用研究计划项目（2011C21010）；浙江省杰出青年人才基金资助项目（R1090833）
National Natural Science Foundation of China（No. 50805130）;

Research Fund for the Doctoral Program of Higher Education of China（No. 20103317110002）;

Zhejiang Provincial Funds for Distinguished Young Scholars( No. R1090833)

Experimental Research on Hydrodynamic Effect of Inclined Micro-pored Gas Face Seals

Bai Shaoxian;Bai Linqing;Meng Xiangkai;Li Jiyun;Peng Xudong

Zhejiang University of Technology, Hangzhou, 310032

Online:2013-03-25 Published:2013-04-08
Supported by:

National Natural Science Foundation of China（No. 50805130）;

Research Fund for the Doctoral Program of Higher Education of China

（No. 20103317110002）;

Zhejiang Provincial Funds for Distinguished Young Scholars
( No. R1090833)

摘要/Abstract

摘要：

对密封压力影响下倾斜微孔端面的气体润滑动压效应进行了实验研究，采用石墨动环和SiC静环配副实现旋转气体润滑。静环试件端面加工有与直径成一定倾斜角度的椭圆微孔，实验中对4种微孔端面的气体润滑膜厚度进行了测量，分析了密封压力和转速对气膜厚度的影响规律。结果表明：转速越高，气膜厚度越大，动压效应越强;密封压力越高，动压效应对膜厚的影响越小;双列倾斜微孔端面的动压效应优于单列倾斜微孔端面的动压效应。


关键词: 倾斜微孔, 密封压力, 气体润滑, 动压效应

Abstract:

Hydrodynamic effect of inclined micro-pored gas face seals was investigated experimentally herein.The tests were carried out on a rotating seal set-up consisted of a carbon rotor and a SiC stator, where the stator was textured with inclined ellipse micro-pores. Film thickness of four textured faces was measured and discussed in different cases of seal pressure and rotating speed. Results show that the inclined ellipse micro-pored seal faces have obvious hydrodynamic effect in gas lubrication cases. Film thickness increases with increasing rotating speed, while influence of hydrodynamic effect on the film thickness decreases with increasing seal pressure. Faces with double-row inclined micro-pores have larger hydrodynamic effect than those with the single-row.

Key words: inclined micro-pore, seal pressure, gas lubrication, hydrodynamic effect

中图分类号:

TH117.2

白少先, 柏林清, 孟祥铠, 李纪云, 彭旭东. 倾斜微孔密封端面气体润滑动压效应实验研究[J]. 中国机械工程, 2013, 24(6): 831-835.

BAI Shao-Xian, BAI Lin-Qing, MENG Xiang-Kai, LI Ji-Yun, BANG Xu-Dong. Experimental Research on Hydrodynamic Effect of Inclined Micro-pored Gas Face Seals[J]. China Mechanical Engineering, 2013, 24(6): 831-835.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: http://www.cmemo.org.cn/CN/

http://www.cmemo.org.cn/CN/Y2013/V24/I6/831

参考文献

[1]Etsion I, Burstein L. A Model for Mechanical Seals with Regular Microsurface Strueture[J]. Tribology Transactions, 1996,39 (3) : 677-68:3.
[2]Etsion I, Halperin G. A Laser Surface Textured Hy- drostatic Mechanical Seal [J]. Tribology Transac- tions, 2002,45 (3): 430-434.
[3]Kligerman Y, Etsion I. Analysis of the Hydrody- namic Effects in a Surface Textured Circumferential Gas Seal[J]. Tribology Transactions, 2001,44 (3) :472-478.
[4]McNikel A D, Etsion I. Near--contact Laser Surface Textured Dry Gas Seals[J]. ASME Journal of Tri- bology,2004,126(4) :788-794.
[5]Feldman Y, Kligerman Y, Etsion I. A Hydrostatic Laser Surface Textured Gas Seal[J]. Tribology Let- ters, 2006,22(1) :21-28.
[6]秦浩[1,2],彭旭东[1,2],白少先[1,2],盛颂恩[1,2],李纪云[2].激光加工多孔气体端面密封的静压性能研究[J].摩擦学学报,2009(3):205-209.
[7]白少先[1,2],彭旭东[1,2],孟祥铠[1,2].激光多孔端面气体非接触机械密封稳定性分析[J].摩擦学学报,2010(6):521-526.
[8]Bai Shaoxian, Peng Xudong, Li Yefeng, et al. A Hy- drodynamic Laser Surface Textured Gas Mechanical Face Seal[J]. Tribology Letters, 2010,38 (2) : 187- 194.
[9]BaiShaoxian,Peng Xudong, Bai Linqing. Experimen- tal Investigation of an Inclined Ellipse Dimpled Gas Face Seal[J]. Tribology Transactions, 2012,55 (4) 512-517.
[10]柏林清[1],白少先[1,2],彭旭东[1,2],孟祥铠[1,2],李纪云[1,2].倾斜微孔端面气体密封的动压特性研究[J].摩擦学学报,2011,31(2):97-103.
[11]李叶枫[1],盛颂恩[1,2],白少先[1,2],彭旭东[1,2].多孔端面气体密封无压开启特性的实验研究[J].润滑与密封,2010(8):8-11.
[12]柏林清[1],马媛媛[1],白少先[1],孟祥铠[1],彭旭东[1].倾斜微孔表面气体润滑动压特性实验研究[J].中国机械工程,2012,23(12):1467-1469.