#br#
Vibration Response Localization of  Bladed Disk with Different Shrouded Fit Modes

China Mechanical Engineering ›› 2012, Vol. 23 ›› Issue (16): 1920-1924,1961.

Previous Articles Next Articles

#br# Vibration Response Localization of Bladed Disk with Different Shrouded Fit Modes

Wang Ailun;Cao Xuhui;Sun Bohai

Key Laboratory of High Performance and Complex Manufacturing,Central South University,Changsha,410083

Online:2012-08-25 Published:2017-05-27
Supported by:

National Program on Key Basic Research Project (973 Program)（No. 2007CB707706）

不同冠间配合叶盘系统振动响应局部化问题研究

王艾伦;曹旭辉;孙渤海

中南大学高性能复杂制造国家重点实验室,长沙,410083

基金资助:
国家重点基础研究发展计划（973计划)资助项目(2007CB707706);中南大学研究生学位论文创新项目
National Program on Key Basic Research Project (973 Program)（No. 2007CB707706）

Abstract

Abstract:

A continuous parameter model with different shrouded fit modes was established.The characteristics of vibration localization of bladed disk under different conditions were compared,and the vibration discipline of different bladed disks was researched.The results show that the vibration localization will not appear in bladed disk with loose fit under tuned conditions,and the sub-tuned vibration and faint vibration localization will appear in bladed disk with tight fit under tuned conditions due to frictional factors,
while the vibration localization will appear in bladed disk with loose fit under random mistuned conditions,and the sub-tuned periodic vibration will not appear in bladed disk with tight fit under random mistuned conditions,and the vibration response localization is more complicated.The vibration localization of bladed disk with loose fit is more sensitive to random mistuning than the vibration localization of bladed disk with tight fit.

Key words: shrouded fit mode, bladed disk, random mistuning, vibration response localization

摘要：

建立了考虑冠间配合形式的自带冠叶盘系统连续参数模型,对比分析了谐调和随机失谐两种状态下冠间紧配合和松配合叶盘系统振动局部化特征,揭示了不同冠间配合叶盘系统的振动规律。研究发现,谐调状态下,冠间松配合自带冠叶盘系统不会出现振动局部化现象,而冠顶摩擦导致冠间紧配合自带冠叶盘系统
亚谐振动的发生,并且出现了较弱的振动局部化现象;叶片随机失谐状态下,冠间松配合叶盘系统将不再具备严格的单周期振动特征,冠间紧配合叶盘系统不再出现严格的亚谐振动,振动响应局部化的复杂性增加;与紧配合自带冠叶盘系统相比,松配合自带冠叶盘系统的振动响应局部化对随机失谐更敏感。



关键词: 冠间配合形式, 叶盘系统, 随机失谐, 振动响应局部化

CLC Number:

WANG Ai-Lun, CAO Xu-Hui, SUN Bo-Hai. #br# Vibration Response Localization of Bladed Disk with Different Shrouded Fit Modes[J]. China Mechanical Engineering, 2012, 23(16): 1920-1924,1961.

王艾伦, 曹旭辉, 孙渤海. 不同冠间配合叶盘系统振动响应局部化问题研究[J]. 中国机械工程, 2012, 23(16): 1920-1924,1961.

References

[1]Ferleger J, Paryington A J. Steam Turbine Blades with Butted Integral and Side Entry Rods [C]// Proceeding of the American Power Conference. Chi- cago, 1993.
[2]Kaneko Y, Mori K, Ohyama H. Development and Verification of 3000rpm 48inch Integral Shroud Blade for Steam Turbine[J]. JSME, International Journal, 2006,49 (2) . 205-211.
[3]Menq C H, Chidamparam P, Griffin J H. Friction Damping of Two Dimensional Motion and Its Ap- plication in Vibration Control[J]. Journal of Sound and Vibration, 1991,144(3) : 427-447.
[4]Cigeroglu E. One Dimensional Dynamic Micro Slip Friction Model[J]. Journal of Sound and Vibration, 2006,292(3/5) :881-898.
[5]Sanliturk K Y, Ewins D J. Modeling Two Dimen- sional Friction Contact and Its Application Using Harmonic Balance Method[J]. Journal of Sound and Vibration, 1996,193(2) : 511-523.
[6]Kaneko Y, Mori K, Ohyama H. Development and Verification of 3000rpm 48inch Integral Shroud Blade for Steam Turbine JJ. JSME, International Journal, 2006,49 (2) : 205-211.
[7]南国防[1],任兴民[1],何尚文[1],杨永锋[1].航空发动机自带冠叶片减振特性研究[J].振动与冲击,2009,28(7):135-138.
[8]Petrov E P. Method for Direct Parametric Analysis of Nonlinear Forced Response of Bladed Disks with Friction Contact InterfacesEC//ASME Turbo Ex- po 2004 . Power for Land, Sea and Air. Viena, 2004 : 654-662.
[9]王红建[1],贺尔铭[1],余仕侠[1].具有干摩擦散乱失谐的叶盘受迫响应特性[J].航空动力学报,2006,21(4):711-715.
[10]Basu P, Griffin J H. The Effect of Limiting Aero- dynamic and Structure Coupling in Models of Mis- tuned Bladed Disk Vibration[J]. ASME Journal of Vibration,Acoustics, Stress, and Reliability in De- sign, 1986,108 : 132-139.
[11]王红建.复杂耦合失谐叶片—轮盘系统振动局部化问题研究[D].西北工业大学,2006:
[12]徐大懋[1],李录平[2],须根发[3],侯绍华[4],汪燕[2].自带冠叶片碰撞减振研究[J].电力科学与技术学报,2007,22(1):1-6.

#br# Vibration Response Localization of Bladed Disk with Different Shrouded Fit Modes

不同冠间配合叶盘系统振动响应局部化问题研究

PDF

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 7

Recommended Articles

Metrics

[1]	DIAO Zhi-Ban, HE Er-Ming, WANG Gong-Jian, CHEN Yi. Experimental Investigation on Frequency Veering and Mistuning Sensitivity of Bladed Disks [J]. China Mechanical Engineering, 2013, 24(1): 73-77.
[2]	WANG Ai-Lun, LI Shuai. Forced Response Characteristics of Mistuned Bladed Disk with Breathing Crack [J]. China Mechanical Engineering, 2013, 24(02): 169-174.
[3]	WANG Ai-Lun, SUN Bo-Hai. Analysis of Natural Vibration Localization of Random Mistuned Bladed Disk with Grouped Blades [J]. China Mechanical Engineering, 2011, 22(7): 771-775.
[4]	WANG Ai-Lun, LI Lin. Study on Vibration Control of Bladed Disk Structure Considering Circuit Mistuning [J]. China Mechanical Engineering, 2011, 22(12): 1387-1392.
[5]	WANG Ai-Lun, HUANG Hui-Fan. Research on Test Method of Mistuned Bladed Disk System Vibration Based on Bond Graph [J]. China Mechanical Engineering, 2010, 21(13): 1513-1518.
[6]	WANG Ai-Lun, HUANG Fei. Vibration Characteristics Analysis of Bladed Disks with Two Interphase Cracked Blades [J]. China Mechanical Engineering, 2010, 21(11): 1270-1274.
[7]	Wang Hongjian;He Erming;Zhao Zhibin. Effects of Frequency Veering Features on Mode Localization of Mistuned Bladed Disks [J]. J4, 2009, 20(01): 0-4.